Poultry Manure Dryer Manufacturer in Norway
See how we dry Poultry ManureLooking for poultry manure dryer manufacturers in Norway? STRONGA builds FlowDrya lines to order at its Hertfordshire works and supplies them to Norway — see the regulatory and economic context below.
FlowDrya poultry manure dryers are built to order at STRONGA's Hertfordshire works and supplied to farms and fertiliser processors here, with no commissioned line on home soil to cite. Poultry litter is a wet, odorous, ammonia-rich residue that the 2009 landfill ban keeps out of burial, so it must be recovered as a soil product or a fuel. To sell it as a fertiliser it must meet gjodselvareforskriften, whose quality classes 0, I, II and III cap heavy metals and contaminants. Litter can reach the shed at around 65 per cent moisture; drying it toward 15 per cent kills pathogens, locks in nitrogen, halts the smell and yields a stable, transportable product. Broiler and layer sheds both benefit, and a granulated or pelletised output spreads evenly through conventional farm machinery.
Supplying Norway
We supply Norway from our Hertfordshire works — we have no documented Poultry Manure installation in Norway yet.
Regulatory context
Norway's waste and pollution regime rests on the Pollution Control Act (forurensningsloven) and the Waste Regulations (avfallsforskriften) of 1 June 2004. Chapter 9 governs landfills: under section 9-7 anyone operating a landfill must hold a permit under the Pollution Control Act, and section 9-4 prohibits the landfilling of wet, biologically degradable organic waste. As an EEA member Norway adopts most EU waste law through the EEA agreement, so the waste hierarchy places recovery above disposal. Turning a wet residue into a fuel or a stabilised soil product is a recovery route ranked above burial.
Source: https://lovdata.no/dokument/LTI/forskrift/2004-06-01-930/KAPITTEL_9 · checked 2026-08
From 1 July 2009 Norway extended the disposal ban to cover all biologically degradable waste sent to landfill, not only wet food and sludge fractions. The ban bites where total organic carbon exceeds 10 per cent or loss on ignition exceeds 20 per cent, so residual waste, paper, wood and natural textiles can no longer simply be buried. The Environment Agency (Miljodirektoratet) designed the ban to cut methane and push degradable material into recycling and energy recovery instead. It is the single strongest driver for drying and diverting wet residues in this market.
Source: https://www.miljodirektoratet.no/ansvarsomrader/avfall/for-naringsliv/deponere-avfall/deponering-av-avfall-forskriftskommentarer/-9-4-forbud-mot-deponering-av-visse-avfallstyper/ · checked 2026-08
Chapter 10 of the Waste Regulations (forbrenning av avfall) governs the incineration and co-incineration of waste. Section 10-4 requires a discharge permit, section 10-6 covers co-incineration plants such as cement kilns, and the chapter fixes the combustion conditions and air- and water-emission limit values a plant must meet. A cement kiln or energy-from-waste plant burning refuse- or solid-recovered fuel operates under this chapter, and a dried, consistent, low-moisture fuel is what keeps such a plant reliably inside those limits.
Source: https://lovdata.no/forskrift/2004-06-01-930 · checked 2026-08
Compost, digestate and sludge-derived products placed on the Norwegian market must comply with the fertiliser regulation for products of organic origin (gjodselvareforskriften), revised on 29 January 2025. It sorts products into quality classes 0, I, II and III according to their heavy-metal content, restricts contaminants such as plastic and glass, and sets rules for declaration before sale. A dried, stabilised material holds those class limits far more readily than a wet, actively degrading feedstock.
Source: https://lovdata.no/dokument/SF/forskrift/2025-01-29-116 · checked 2026-08
Applicable standards: EN ISO 21640, EN ISO 17225-4, EN ISO 18134, gjodselvareforskriften quality classes 0, I, II and III.
Economic context
Norway runs one of the world's highest carbon prices. The general CO2 tax on non-quota emissions stood at NOK 952 per tonne of CO2 in 2023, and the government's climate plan sets a course to raise the general rate toward NOK 2000 per tonne by 2030 (in 2020 kroner). Every tonne of fossil fuel a dried waste- or biomass-derived fuel displaces avoids a real and steeply rising carbon cost.
Source: https://www.ssb.no/natur-og-miljo/artikler-og-publikasjoner/okonomien-i-regjeringens-klimaplan-mot-2030 · checked 2026-08
Land-based industry also pays for carbon under the EU Emissions Trading System, which Norway joined through the EEA. The allowance price was equivalent to around NOK 1000 per tonne of CO2 in 2023, and roughly 85 per cent of Norwegian greenhouse-gas emissions are covered by either the CO2 tax or the ETS. That double exposure sharpens the value of substituting coal or coke with a recovered fuel.
Source: https://energifaktanorge.no/en/et-baerekraftig-og-sikkert-energisystem/avgifter-og-kvoteplikt/ · checked 2026-08
Conversion cost hinges on cheap heat, not electricity. Statistics Norway (SSB) put the electricity price for energy-intensive industry at 42.2 ore per kWh in the third quarter of 2025, excluding taxes and grid rent. Boiling water off a wet residue with electrical resistance heating would waste that power, so a dryer that runs on recovered process, exhaust or kiln heat and very little electricity is what keeps drying economic.
Source: https://www.ssb.no/en/energi-og-industri/energi/statistikk/elektrisitetspriser/article-for-electricity-prices/slightly-higher-electricity-price-in-third-quarter · checked 2026-08
State enterprise Enova, funded through the Climate and Energy Fund, offers investment aid for renewable heat and district-heating plants, industrial biogas production, energy recovery in industry and full-scale climate-technology demonstration. That support helps underwrite the heat plant and process changes a drying and fuel-preparation project needs.
Source: https://www.iea.org/policies/2617-enova-and-the-climate-and-energy-fund · checked 2026-08
Worked illustration (assumptions stated):
The economics rest on nutrients, haulage and odour. A dried litter is a concentrated, storable fertiliser that can be bagged and carted to arable farms, where a wet, degrading manure cannot travel far or be spread evenly. Meeting a gjodselvareforskriften class opens that market; failing it means costly disposal. Retaining ammonia as plant-available nitrogen rather than losing it to the air also raises the agronomic worth of every tonne sold. Firing the dryer on recovered heat rather than grid power at 42.2 ore per kWh keeps conversion cheap, and its stop-start moving floor draws 4X less electricity than a belt dryer. Where the litter is burned for heat instead, displacing fossil fuel avoids a CO2 tax of NOK 952 per tonne rising toward NOK 2000. Assumptions stated: nutrient value, haulage distance and heat source govern payback.
Figures are indicative and were last reviewed August 2026; energy and disposal prices move — contact us for a current assessment.
Poultry Manure Dryer Manufacturer in Norway — FAQ
Do you supply poultry manure dryers here?
Yes, from our Hertfordshire factory. We hold no commissioned litter line on home soil yet and will not imply one; the platform is the same continuous-flow FlowDrya proven on our British reference sites.
How does the fertiliser regulation apply?
Products of organic origin are graded by gjodselvareforskriften into quality classes 0, I, II and III on heavy-metal content. A dried, stabilised litter holds a class far more reliably than a wet, actively degrading manure.
Why dry poultry litter?
Litter near 65 per cent moisture is heavy, smelly and biologically active. Drying it toward 15 per cent kills pathogens, locks in nitrogen, stops the odour and yields a stable product a farm can store and spread.
Does the landfill ban apply to manure?
Yes. The 2009 ban keeps wet, biodegradable organic waste out of landfill, so litter must be recovered as a fertiliser or a fuel rather than buried.
How much electrical power does the dryer use?
Its intermittent moving floor draws 4X less electrical power than a belt dryer and is designed to run on recovered heat, so it needs little grid electricity at 42.2 ore per kWh.
How is a plant shipped and commissioned from the UK?
Each dryer is fully assembled and factory-tested at our works, then dismantled for freight, reassembled on site, connected to the heat supply and brought online through a supervised trial before handover.